Having problems with your Jeep CJ ?

WIRE PROBLEM I have restored a 1948 jeep willys cj2a and now ready for the elec. and only have some factory to go from. need to know the location of wires from dimmer switch,brake switch,key switch(three wire),push button start & fuel gauge. the system is 6volt and has a 6volt starter relay being used. (I have all new parts)but I can only get the headlights,park,& ammeter to work.

Posted / edited by AnonymousUser on : 22-01-2018

Answers :

. The company in the link below will have everything u need, harnesses and info on how to hook them in.
\015\012
\015\012http://www.tellico4x4.com/index.php/cPath/143_499
Repair Help & Product Troubleshooting for Jeep CJ

Tips for a great answer:

- Provide details, support with references or personal experience .
- If you need clarification, ask it in the comment box .
- It's 100% free, no registration required.

Suggested Questions/Answers :

WIRE PROBLEM I have restored a 1948 jeep willys cj2a and now ready for the elec. and only have some factory to go from. need to know the location of wires from dimmer switch,brake switch,key switch(three wire),push button start & fuel gauge. the system is 6volt and has a 6volt starter relay being used. (I have all new parts)but I can only get the headlights,park,& ammeter to work.


. The company in the link below will have everything u need, harnesses and info on how to hook them in.\015\012\015\012http://www.tellico4x4.com/i ... Jeep CJ

1996 royal star Couple days ago bike lost power randomly while stopping or cruising down the road. I changed fuel filter and checked fuel pump operation. Later that day bike lost power while stopping again. I read the starter cutout relay can cause, so I got used one. Now when I hit start button with kill switch on run it pops ignition fuse . However when I push start button with kill switch on off the engine cranks great but no spark . Ant ideas?


... Cars & Trucks

I have a 96 chevy s-10. When I turn the key my gauges, warning lights or my fuel pump will come on. My radio will work when the key is on as well as the starter will turn the motor over. I have replaced the relays behind the golve box with new ones. I let the truck sit for a couple of weeks and went out and it started. After driving up the road a few miles, I started back home. On the way back all the gauges on the dash went dead and the truck stalled but came back to life. After I got home and


Sounds simple but inspect battery cable tension at the battery...snug up with 6pt 8mm or 5/16" socket/wrench. ... 1996 Chevrolet S-10 Pickup

2001 jeep chreoke ltd v8 wont start starter turns , have checked relays and changed fuel pump when ign is turned on fuel gauge goes to full tank but only half full any suggestions??? whats wrong//


Cmp. ... 2000 Jeep Grand Cherokee

1994 plymouth acclaim. I dropped off my son last week, got out of car and when I got back in I could not get it started. Starter relay was buzzing, i bypassed relay with remote starter button and starter only emitted a high pitched soft whine but did not turn over. Replaced starter and replaced battery and removed remote switch and tried to start car. The relay is still buzzing and car not starting. Don't understand why car wouldn't start with bypassed starter switch.


Welcome to Fixya\015\012\015\012Starter relay switch control the starting solenoid. The starter relay provides power to the starter when the key switch is turned to "Start." The starter relay acts like an electrical switch routing battery ... 1994 Plymouth Acclaim

Car will not start. car will run for a moment or two if I pour gas in the fuel injection manifold. The fuel gauge is pegged to overfull. all other gauges seem to work fine. Fuel gauge remains pegged even with the fuel pump electric wires disconnected. I believe it is a bad fuel pump relay or the the low oil pressure sensor switch is disabling the fuel pump relay. However I cannot locate the fuel pump relay?


The oil pressure sending unit will be the problem for that primes the pum when you turn the key to the on position. You will hear the fuel pump running for 5 seconds when doing that. If the pump is running when you have the key turned to the ON posit ... 1992 Buick Roadmaster

Why is the fuel relay buzzing and car won't start? the dash lights are flickering on and off, and the relay buzzes for like 3-5 seconds, and the startes just keeps trying to turn over the engine. it started shutting off wehile driving one day, and the dash lkights started to flicker,a dn this happened a couple times over about a weeks worth of time, and then it hasn't started since. i was told to replace the starter, the fuel pump relay, and they are also suggesting the fuel pump be changed, but


I had a similar problem and though it was my alternator, it turned out it was the fuel pump, and you have to drop the fuel tank out to get to it, very expensive, but fixed the problem and runs fine now. ... 2004 Pontiac Sunfire

I went out to warm it up,it started fine.When I came out to leave,it was dead.All of the instrument cluster lights were on but it wouldnt crank and i am not getting a fuel pump.I checked the battery,all of the fuses and relays.I replaced the ignition switch,still nothing.Ichecked for power at the starter relay,fuel pump relay and ASD relay.I have power to all of them on 2 pins.I even have power to the yellow start wire on the starter relay when I turn the key to start.Im not getting any crank or


First unhook the battery for about a half hour to reset the computer.\015\012does that have anti-theft on it.\015\012a remote starter ?\015\012second either swap the relays for the starter and fuel pump or replace them outright. ... Chrysler PT Cruiser

I have a 2002 jeep grand cherokee (2 WD, 4.0L), it seems that when I try to start it (cold or hot) it won't immediatly start, the starter going fine but it seems like no fuel is getting to the injectors, I changed the fuel filter and this worked for a day. However if I pull the relay and depressurize the system it will start immediatly after replacing the relay. The system is pretty clean because when I changed the fuel filter the fuel comming out was clean.


May be a faulty fuel pump ... 2002 Jeep Grand Cherokee

My friends Jaguar xj6 1997 won start or crank. Drove car to work. Didnt start on the way home. Tried **** the gear stick. Inertia switch ok. Locked with key,held to set alarm,unlocked and turned key....didnt start. Got power to fuel relay fuse. Fuel pump dont start when key is turned. Did connect power to the white cable on the back of the valve cover that cranced the starter so solenoid and starter is ok. Tried both keys. What to do? Heard something about ground fault with the starter. Or the


... 1997 Jaguar XJ6

I HAVE 93 CHEVY 1500 TRUCK 5.7 V-8.WONT START,STARTS WITH STARTER FLUID AND DIES UNPLUG FUEL PUMP RELAY ENGINE STARTS AND RUNS WITH RELAY UNPLUGED THEN PLUG RELAY BACK AND THE ENGINE DIES AND WONT RESTART UNTIL FUEL RELAY IS UNPLUED.THEN THE ENGINE RUNS A LITTLE OVER HIGH IDLE.


... 1999 Chevrolet Silverado 1500

Car won't start when I turn the key to start the #10 fuse engine relay pops I checked every thing down to the fuel pump and every thing is fine the few times I got it started I took it around the block and the fuse poped again and car stalled I took out the starter fuse and put the #10engine relay back in and turned the key to start to my suprise it didn't blow out then attempted to put the starter fuse in and immediately the #10 engine relay fuse blew out I repeated it again and the same thing


I had a similar problem where the battery was ok \012but there was no sound from the starter and also there no lights on in \012the dash when the key was turned. Checked the fuse and checked wire \012from the fuse back to the ignition switch. ... 2000 Dodge Neon

Car runs, but stalls. All power indicators on. Car rests, then starts. Runs for short distance, then stalls again. Tests indicate no power to starter from ingnition leads when keying to start. Already replaced starter solenoid relay, fuel pump relay, auto shut-down relay and bypassed starter motor. Applied power directly to starter and it cranks. Now, turning key does nothing. This vehicle has key decoder module. Do I need to replace this module????


Check for proper current from alternator more than13.5 volts that should do it if not check active codes if its not stolen ... 2003 Chrysler Town & Country

1992 Honda Accord we are trying to fix for son. Been sitting 6 years. Tries to start but won't turn over. Have replaced main relay. Will run a few seconds if we spray starting fluid in intake. Also changed fuel filter. Gas gauge not showing any fuel even though we put in 5 gal. fresh gas.After trying to crank we loosened fuel line and does not seem to be any fuel going to injecters. Can't hear fuel pump, but wondering if there is a fuse or separate relay for fuel pump etc. before we tackle fuel


Hi\015\012\015\012There are quite a few potential causes of this in a car that has been sitting up for 6 years. These can range from a problem with the cars ignition switch to a bad coil (faulty coil will cause fuel pump not to operate on ... Honda Accord

When i turn the ignition, i get the normal chime, all the gauges reset, and then i hear a buzzing sound from under the hood, and the car won't start. when i looked into it closer, i discovered it is the fuel pump relay buzzing. i have replaced it twice, the starter, and all the spark plugs and wires, cause a friend of mine told me it might be a spark issue. none of these things have helped, and i'm told that it might be a ground wire. can anyone help with this? i need a description that i can ac


These GM's are famous for their side post battery issues. Double check your contacts at the battery first and then voltage standing. If it's below 11v replace it. ... 2003 Pontiac Sunfire

My husband states no power in fuel pump;has no power in igniction coil;has no in starter--only does click,click. that all he has checked so far.Scanner does not give out any codes. Comments: Jun 25, 2009- it cant be the battery because--my husband runs a ground wire to relay of starter and it starts. But--it wont get power to start fuel pump or ignition coil. it will start sometimes and then stops after 5 minutes.then it wont start again for another hour. does it have an automatic shut down? ple


Well it sounds like you have a relay problem. It can do that. The terminal you speak of probably has nothing to do with starter at all. a flasher or something, so unplug in and see if the signal light stop working. Firstly check to see if ... 2000 Dodge Caravan

Starting system I need to know a starting system from ignation switch to the starter motor. I can,t find a scematic diagram enywhere. It won,t start. starter motor ok. I can by pass it and start. I can,t find any relay outside on the firewall.( sorry two relays. One for fuel pump, but another axuarly) Is there anything else? [email protected]


1999 f expedition [it craincs but will not fier ] ... 1994 Chevrolet C/K 3500

2001 venture . turn key to start.... nothing,also no fuel pump.but i can jump fuel relay....pump works ,jump starter it works. ok now turn key on and jump fuel and starter still no start but have spark, fuel,and turning over with key on


Hi there I am technical mechanical and electronic engineer mechanic it is ignition switch and ignition key and lock ... 2001 Chevrolet Venture

1999 Yukon cold start problems. I replaced the fuel pump, fuel relay module, fuel filter, fuel pressure regulator, battery, alternator, starter, throttle position sensor, spark plugs, spark plug wires & distributor cap. Fuel pressure is fine 60 psi. Checked for spark, sparks just fine. I put a little gas down the throttle and it started but eventually died. I started having this problem in the mornings only until it gradually worked it's way to not start at all.


1999 Yukon Start Issue - I have replaced the octopuse, battery, fuel filter, fuel pump, still having problems starting in cold weather, sometimes after a heavy rain.\015\012\015\012Any suggestions?\015\012\015\012Thanks ... 1999 GMC Yukon

Wont start! Truck has 4.3L Vortec. Engine Code W and is 4x4 New Alternator, new fuel pump relay, new fuses, Starter is new, Fuel pump just changed, new cap and rotor, new plugs, new fuel regulator!! i had just changed the fuel pump a couple weeks ago and ran fine for the first 40km then it started to run hard and then sputter and turn off! i waited a few hours to try and restart it started fine but the next day i came back to it it was very hesitant to start and once i got it started it did


Think the fuel pump may have a problem-could be a bad new one-chec it out as well as the fuel filter-did u put that in rite and not reverse-what about a clog in the runway for free u can scan car at those discount places ... 1993 Chevrolet S-10 Blazer

I have a 1992 camaro that wont start when you turn the key. It doesnt even engage the starter. The battery and starter were both checked and in good working order. Put push button remote starter on vehicle and it will crank but not run (key is on of course) no fuel to throttle body... poured gas in TBI and vehicle started but quit when fuel burned that was added.... What could be the problem?


It is the factory security system it dis ables fuel sysytem a real pain to fix ... 1992 Chevrolet Camaro

While driving down the interstate, my 1996 Eagle Vision just shut off. I have replaced the fuel pump, fuel filter, spark plugs, coil pack, fuel pump relay, and the starter relay. It still will not start! It has not started since it died on the inerstate. Please help?


Have you checked your timing belt that will cause the issue your having ... 1996 Eagle Vision

I asked this question on feb 5 2002 lincoln ls 38,000 miles fuel gauge went to empty then the next day it wouldnt start & check engine light came on . I replaced fuel pump & fuel gauge did the same thing . I went on line to fix ya they told me to replace fuel filter & fuel pump relay . after i did that i let it run for about 20 minutes then fuel gauge went to empty again but runs fine


The LS Lincoln Has 2 Fuel Pumps . The One On The Drivers Side Is Called A Transfer Pump , It Pumps Fuel From Drivers Side Of Tank To Passenger Side Both Pumps Have Sending Units On Them The Transfer Pump Sending Unit Was Bad ... 2002 Lincoln LS

2002 Durango 4.7L 2wd. It would not start; starter checked [it was ok] and a relay switch replaced. It then started for a short period then it refused to start. I had several scans and point checks done. Nothing was found, but the fuel pump was not getting fuel and I kept getting a “no bus” code. I was told it was the PCM and I had it replaced [flashed and coded]. It still would not start; Replaced fuel pump; would not start; Replaced/fixed catalytic converter-no luck. Replaced ignition


I HAVE A FORD PROBE BUT I HAD THAT PROBLEM WITH MY CAR IT WAS THE FUEL SHOT OFF BUTTON IT WAS A BAD BUTTON SO REPLACED AND IT WORKED SO TRY TAT AND U CAN GET IT TESTED ... 2002 Dodge Durango

I have a 1995 Jeep Grand Cherokee Limited ,when I go to start it, the relay starts clicking and the fuel pump starts pumping after about 15- 20 minutes of leaving the key on. Also the security light comes on. After the fuelpump pumps up pressure the security light will go out, then when I go to start it the RPM gauge and the injectors go wacky. The RPM gauge continues to jump all over until I turn the key off, at the same time the RPM gauge is going all over the injectors are pumping gas, the en


Certainly sounds like a bad fuel pump regulator. You have a 95 so the regulator isn't part of the fuel pump (on 96 and newer its all one assembly.) You don't have a fuel pressure tester by any chance do you? That would be a great tool in this situati ... 1995 Jeep Grand Cherokee
  • Start your question with What, Why, How, When, etc. and end with a "?"
  • Be clear and specific
  • Use proper spelling and grammar
all rights reserved to the respective owners || www.carrestorationshop.com || Terms of Use || Contact || Privacy Policy
Load time: 3.5590 seconds