Having problems with your Cars & Trucks ?

How to remove fuel tank from a 2004 ML 350 mercedes

Posted / edited by AnonymousUser on : 15-01-2018

Answers :

Repair Help & Product Troubleshooting for Cars & Trucks

Tips for a great answer:

- Provide details, support with references or personal experience .
- If you need clarification, ask it in the comment box .
- It's 100% free, no registration required.

Suggested Questions/Answers :

I have a Mercedes A Class 1.6 LWB and when releasing the fuel tank cap the air sucks in . If left for several trips the cap is nearly impossible to remove. When removed one hears the air rush in and a rattling noise from the front of the car. Have replaced the cap but did not fix the problem. Where does the air get into the tank as the fuel is used up?


You need to first check valve for activated charcoal canister and also check function purge valve. ... 1988 Mercedes-Benz 190

Need to remove fuel tank from 75 450sl. Tank is drained ,wall is out,completely disconnected and feels free.When you start to swing the end opposite the filler neck the tank blocks up against something very solid after 3/4 - 1 '' movement. mbz factory manual says tank is ready to come at this point.Cannot see under or in back of tank. What might I be over looking? Have even tried tugging the side with a slide hammer.


... Mercedes-Benz SL-Class

Start truck,runs 1-2 mins.,dies. weather -20c can see vapor from exhaust pipes when running, then vapor stops and truck dies. changed fuel filter, no difference.Installed new fuel pump 4 months ago. any ideas? I am using premium gas and gas line anti-freeze so I would not think freezing is a problem.Also added a bottle of STP product to remove any water in the tank. I believe the fuel should be about 14PSI. to the throttle body injectors.


Hello and welcome to Fixya.com \015\012The use of premium fuel in this truck will cause hard starting in cold weather, premium doesn't mean the fuel is better it just is a catchy word for 91/92 octane fuel, higher octane fuel burns slower and h ... Chevrolet 2500

Sholly, we chatted yesterday about my 98 dodge grand caravan. 1. we dropped the tank to check the fuel pump. we tested the juice to the fuel pump. there is no juice. is there a auto shut off/reset button to the fuel pump? 2. the chilton book is very vague. is there a way to test the relays? 3. also how do you remove the relays to test them? my husband thought they pulled straight out, but they don't. is there a trick to pulling them out ? 3. we read the book, and from what we gather


TESTING\015\012Fuel system pressure testing requires the use of a DRB or equivalent \015\012scan tool.\015\012The fuel pump operates at about 49 psi (338 kPa).\015\012\015\012\015\012 ... Dodge Grand Caravan

1995 Isuzu Rodeo with 3.2L v6. With no power to the fuel pump. I've checked the continuity on the fuel pump wires they seem fine. No/low voltage on the wires to the pump, (.08 volts when DMM is set to 20). Checked pump after removing the tank and the pump, it purred. Checked the fuel pump relay it seems to have power on 1 circuit, (not sure if 2 circuits should have power(?)). Then checked with a known good relay. Then tried jumping/bypassing the relay. The schematic show the power should go fr


Maybe a fuel filter clogged, or a relay to your fuel pump. ... 1997 Isuzu Rodeo

Fuel tank removal mercedes c220 - 1995 Mercedes-Benz C-Class


... 1995 Mercedes-Benz C-Class

I have a 1992 Chevy suburban that I need to change the fuel pump, I already removed the 2 strains from the gas tank but, the only thing that was lowered with the strains was the fuel tank protector, and the fuel tank remain intact on its place without lowered or move, now my question is how can I lowered the fuel tank to remove and change the fuel pump?


There may be a little rust build up form the winter driving and rainy days. i would use a non abrasive wand or rubber coated bar to pry it off. ... Chevrolet Suburban 1500

Can you access the fuel pump without removing tank? Im not getting fuel to the carb. I checked the lines to the fuel filter to carb and from fuel filter to the tank and seems clear. The only thing I can think of is the fuel pump. Any ideas? Also, can you access the fuel pump through the rear of vehicle inside or does the tank need to be removed?


If you have a carburetor, you have a mechanical fuel pump on the engine. If you have a throttle body injection your pump is in the tank and the tank needs to be removed to get at it. Before dropping tank make sure the pump is getting power and a good ... 1988 Chevrolet Suburban

Car doesn't have power its finds difficult going up a hill. recently they put petrol instead of diesel drove for 1 km before stopping and removed the fuel, cleaned the tank and the car started nor


Try changing the fuel filter. If that does not help, have someone test the injector pump for pressure. Last would be a compression test on the cylinders. Drain oil and replace oil filter very soon.\015\012\015\012What has happened is the d ... Nissan Cars & Trucks

How to remove fuel tank from a 2004 ML 350 mercedes


... Cars & Trucks

Fuel pump quit working, dropped the tank and removed wiring harness, have 1 ground and three other wires. When ignition is on two wires have 12 volts the third bigger green and black wire has nothing. When I turn the engine over, same thing. Is this bigger wire controlling the pump and if so where do I start


Hi. That big green and black wire is the ground wire. J. ... Dodge Durango

How many hours does it take to remove a gas tank on a 1995 Mercedes C220 in order to replace the fuel sending unit so that the gas gauge will work? s does


Try this website to download a free manual\012\012Trouble trees are listed for all makes in the manuals for dianogstics\012\012\012\012\012\012\012\012http://ezinearticles.com/?Find-the-Free-Auto-Repair-Manual-You- ... 1995 Mercedes-Benz C-Class

How to remove fuel tank from 1991 Merceded Benz 300D


... 1958 Mercedes-Benz 300D

Im having problem with fuel tank for my mercedes c180 1994 classic model, already replaced with new fuel tank once in 2005 but fuel flow problem happened again after my under carriage hose burst in july 2008.The fuel can only be utilized up to 3/4 of fuel although the indicator shown 1/4 is still in the fuel tank. It become worse after servicing and replaced the fuel pump and my machanic drain out the entire fuel. Now im only can utilized 1/2 of the fuel and anoter 1/2 of fuel in the tank stays


Hi,\015\012\015\012The Problem: The gas tank breather pipe, the tiny pipe which goes from the tank to above the filler cap (Diagram 1, Figure 23) under the locked door is blocked. It occurred to me that I should check it since the tank ha ... 1994 Mercedes-Benz C-Class

I want to replace my fuel pump in my 2002 ford ranger truck. Do I have to remove the gas tank? I was scanning the internet two days ago and found a step by step instruction for removing the fuel pump and I did not see it state that the fuel tank had to be removed. This would be a major obstacle for me to do by myself. Also there was an entry by a person from Idaho which stated that the problem was that the ethanol in the gasoline caused a hose to shrink causing a pressure leak. If this hose was


First of all, if the pump is not working there is no used to replace the hose. the amount of ethanol in the gas is mostly regulated by the government so if there is a problem then people will know about it.\015\012to replace the pump you must r ... 2002 Ford Ranger Regular Cab

Fuel tank removal. Do I need to remove fuel filter first it is in front of tank also anything else that needs to be removed before I lower the tank so nothing breaks Thanks


You should be able to disconnect the fuel line from the pump housing and unplug the sending unit that should be everything you need to disconnect ... 1995 Buick Regal

How do you remove the fuel filler line from the fuel tank? The line appears to be clogged as no fuel seems to go into the tank? Sometimes it will, but very slowly, others it just fills the filler pipe then puddles. Can not figure out how to disconnect the filler line from the fuel tank. There is a flexible connection at the fuel tank but I can not figure out how to disconnect it from the tank itself..


This means your filler flap is stuck closed or your vent solenoid has failed, most likely the vent solenoid. Thanks ... 1999 Daewoo Leganza

Not getting voltage to my fuel pump. Sugar was dumped into my neice's fuel tank. She took it to a shop and they removed the tank and washed it out. They also said the fuel pump was bad, and for $700 they would fix it. She doesn't have that kind of money. I removed the fuel pump and bench tested it, and it worked. As I troubleshot the problem I found that there wasn't any voltage going to the pump. The fuse and relay look good.


Check the oil pressure switch too for the primes the pump when it first starts. the third wire is for the fuel pump and runs only till the engines oil pressure reaches the normal psi. then the relay takes over ... 2004 Chevrolet Venture Passanger

Truck was running great, went to dinner and started the truck and put into gear , and truck died, so had truck jumped and the driver said no fuel, most likely bad fuel pump, so a friend and I removed the fuel tank, and dropped the tank, and removed both of the wiring harness connectors, and then replaced the fuel pump accordingly to the directions, and they gave me a new 4 wire wiring harness , with color coded wires, and used the conntectors to the wires , and then plugged the plugs into the ne


U are sure you have the repair connector hooked up correctly? is the wire to oil pressure cutoff switch hooked up? ... Chevrolet S 10

I need to remove the fuel pump on a 1995 dodge spirit and im not exactly sure where it's located on the tank. Is it on the top of the tank or on the back of it? Also do i have to remove the tank to take it out or if it is on the back can i leave the tank on and just take out the fuel pump?


IT SHOULD BE IN THE FUEL TANK ... 1995 Dodge Spirit

How do I remove the bed from 2000 F250 Super Duty quad cab diesel short bed? I need to change the fuel sending unit in the fuel tank and think removing the bed may be easier than the fuel tank.


The F250 may be different, but read the Haynes manual for my rAnger once and after 2 hours of knuckle busting and little luck, I went for the bed. 6 bolts, 2 taillight quick connects, and a hoseclamp later (maybe 20 mins) the bed was off and I had t ... 2000 Ford F250 Super Duty Crew Cabs

How do remove a fuel pump from the fuel tank once the fuel tank has been removed from the vehicle. please provide step by step instructions. this is for a 2000 oldsmobile silhoutte


On the top of tank where the gas lines come out of it there is a locking ring there. use a hammer and punch .tap the ring counter clock wise to unlock ... 2000 Oldsmobile Silhouette

I am changing the fuel pump on a 2002 Pontiac Gran Am. I unhooked all of the lines and removed the tank straps, but the tank still will not drop down. I thought that something might be holding it in from the top, so I removed the back seats and there doesn't appear to be anyway to access the fuel tank from the top.


It should just drop out it might be jamed give it a little elbow grease and it shouldcome right out ... 2002 Pontiac Grand Am

I can't remove the fuel lines from the fuel pump on top of the gas tank I drained the gas, lowered the tank bought the tool to remove the lines but i can't seem to remove the line any why it's eather the wrong tool or i'm just being stupid


If they are the metal end ones you insert the toolin and push in on line and then pull back see if that works for ya ... 1999 Chevrolet Blazer

I replaced the fuel filter and fuel lines from the tank to the fuel pump but did not replace the fuel pump. I drained the tank and it took forever for all the gas to drain out of the tank. I now have everything back in and the 1983 Mercedes 380SL will not start. Do I need to purge the fuel lines at the engine?


CHECK FUEL PUMP FUSE AND RELAY.IF ONE OF THEM IS FAULTY THE FUEL PUMP WONT RUN. ... 1983 Mercedes-Benz 300-Class
  • Start your question with What, Why, How, When, etc. and end with a "?"
  • Be clear and specific
  • Use proper spelling and grammar
all rights reserved to the respective owners || www.carrestorationshop.com || Terms of Use || Contact || Privacy Policy
Load time: 2.7260 seconds