Having problems with your 2004 Saturn ION ?

2004 saturn ion radiator cooling fan wiring - 2004 Saturn ION

Posted / edited by AnonymousUser on : 15-01-2018

Answers :

Repair Help & Product Troubleshooting for 2004 Saturn ION

Tips for a great answer:

- Provide details, support with references or personal experience .
- If you need clarification, ask it in the comment box .
- It's 100% free, no registration required.

Suggested Questions/Answers :

2004 saturn ion radiator cooling fan wiring - 2004 Saturn ION

... 2004 Saturn ION

92 saturn sl2 1.9 liter engine have problem with cooling fans not coming on. Relaced relay in fuse box , jumped wire to fan motor, fan motors works. took wire off cooling sensor and jumped . fan still would not come on, but engine idle would go up. ac system is fully charged and blowing cold air. can you help me?

... 1992 Saturn SL2

Location of oil pressure sending unit on 3 8 engine, on an 1986 Oldsmobile brougham? Also I am replacing the radiator which had a disconnected, what looked like a cooling sending unit located on the side of the radiator? Is this where the cooling unit sending unit is located? My cooling fan does not appear to be working properly, so I would like to know, if I can straight wire the fan motor with a toggle switch, by bypassing the relay? I am attempting to install a set of gauges mounting insi

... 1986 Oldsmobile Regency

1990 LeBaron 3.0 engine. Radiator cooling fan replaced not turning on to cool engine, thermostat and sensor was replaced also. Worked for awhile, now not working. Any suggestions? Wiring? Water Pump is okay. How many relays or sensors is there to turn on the radiator cooling fan?

Those old style relays in the steel cases mounted on th fender under the hood were good for falling arart inside.check the fan reay ... 1990 Chrysler LeBaron

The cooling fan does not go on and the temperature gauge does not show signs of overheating but it over heats and comes out of the little over flow hose. The fan does come on with the ac running. I only put water in the radiator cause of the fan not turning on when it should. I change the radiator, thermostac,water pump, and the temperature cooling sensor. So I need to check the wires for a short or something

After replacing all that its going to take the fan awhile to kick on but tis going to over heat fast with just water its got alot lower boweling point than coolant may be doing this faster than what the fan can kick on ... 1996 Mazda Millenia

Land rover 2008 LR2 radiator fan does not work. Power and grounds.Ok. Purple wire from engine control module to cooling fan control unit (at radiator fan shroud) is questionable. What should be the proper signal? variable voltage,grounds. or frequency. What should I see on this wire?

... Land Rover LR2

2004 VOLKSWAGEN PASSAT 4 DOOR 4 CYLINDER TURBO Air Conditioning System ? A/C System only cools (moderately) at highway speed. Take to shop and tech?s recharge system... does not cool... They say condenser fan will not engage because fan or relay is defective. They replace the whole fan assembly, radiator fan, condenser fan, wiring harness, relays, etc... still does not cool ... Tell me to drive it a few days to see if dye shows a leak ... No apparent leak... Where do I go from he

... 2004 Volkswagen Passat

1999 Saturn SW2 overheats and bubbles in resevoir. So far the water pump, radiator and thermostat have been replaced. Also some wiring from fan to fuse box rewired. All by dealership 4 days ago. T

... Cars & Trucks

I have a 97 dodge grand caravan that has a cooling fan problem. I have replaced the fans, radiator, col temp sens, fan relay, fuses and the fan still does not come on. i did notice the previous owner cut into the fans power wire and ran it to the radio fuse under the dash. I disconected that and reconnected stock wiring now my ? is do i need to flash my cpu for the fans to engage?

Make sure the fans are well grounded. You can temporarily jump 12 volts from the battery to the fans in order to check if they work. The new relay also could have been compromised if the wiring was incorrect before. ... 1997 Dodge Grand Caravan

The cooling fan on the 02 saturn sc1 is not working and the vehicle is overheating. I changed out the fuse and relay and no luck. I noticed the wires the plug into the fan had been laying on the exhast manifold and the rubber was mellted down to bare wire But the wire look intact. Could this be my problem or the thermostat or the fan motor itself. How do I determine which is the problem and how do I fix it

Did you find a reslotion to this? I have the same problem, replaced relay, fuse, fan and thermostat. it worked fine for about 30 minutes and fan quit again! ... 2002 Saturn S-Series

I have a 2008 Town and Country and the temp gage gets to dead center and I smell antifreeze. Never remember the gage ever reaching the center before either. So I Checked to see if the radiator cooling fan comes on. I ran the engine and watched the fan it did not come on. So I turned on the AC and eventually the fan came on. I check the fan, fan relay behind the left headlight, and the Lo radiator relay in the fuse box. The all chek good. The relay behind the light had power and the wire from the

Ok this might sound crazy but you say you smell coolant but never said if you checked to see if it was full posible bad coolant temp sensor or no coolant passing the sensor please more info on coolant usually if low coolant fan will stay on however y ... 2008 Chrysler Town & Country

The starter on my 1995 saturn sl2 stopped working i can still push start the car but in the same day the heater fan and cooling fan stops working but then starts working again when the fans don't work the interior lights dim but when they are working they are fine then just the heater fan stops working but the cooling fan is working is this a wiring problem

You have a electrical power shortage, when componets demand power it's not there [ that's why some componets slow or stop working ]. Start by cleaning the battery terminals and testing the battery to see if it holds a proper charge [ after fully cha ... Saturn SL2

Need a wiring diagram for a 1999 Saturn SL1 for the radiator fan.

... 1999 Saturn SL

I have a 1994 toyota camry and both fans have stop running in front of the radiator. I changed the thermostat, fan cooling sensor plug and nothing happened. I went into the fuse and relay box under the hood and wiggled the green and white fan relay fuse, fan #1 , the fan came on but when pushed in socket to deep the fan has went off and stayed off like a shortage almost. 1 fan works now but is straight wired to the battery. I now have only one fan but I have to lift the hood everytime i get in a

Sounds like you have corrosion at the fuse connection, try taking a small wire item like an unfloded small paper clip to clean that connector in the fuse box and replace that fuse, be cafeful to disconnect the negitive [ - ] battery post before you t ... 1994 Toyota Camry

Saturn ion radiator fan - 2006 Saturn ION

... 2006 Saturn ION

I have a 01' New Beetle my cooling fans come on high speed when the ignition is turned on and stay on while the motor is running. Have already changed out the coolant temp sensor, control module, radiator switch, and two wire switch between the radiator and the motor, I think it is the thermal switch. I think I have narrowed it down to whatever controls the #10 relay in the thirteenfold auxiliary relay panel, ALLDATA calls it THIRD SPEED COOLANT FAN CONTROL (FC) (100). If I disconnect this relay

I finally fixed the problem. It wasn't the Water pump, or the Fan switch or the Green Temp Switch or the Fan Control Module but the "BLACK" NOT White, 2 Pin Thermal Switch 112c" It does sit in between 3 collant hoses where the upper radiator hose ... 2001 Volkswagen Beetle

Engine is getting hot and radiator fan will not come on- would like to test the fan connector plug with jumper wires or the fan temperature switch, the sensor for the fan and the cooling fan relay - do I need a diagram and where can I find one online?

You should have a check engine light on if your coolant temperature sensor is bad. It could be your fan relay. It's position should be located on your fuse box cover(s). To check the fan itself, unplug it and notice that the black (or darkest) wire i ... 1992 Honda Civic

Radiator cooling fan only runs when a/c is on.Changed water temp sensor and fan relay. Can get it to come on if I hook up a test light to one of the two hot wires that goes to fan relay. Where does the fan relay get its contol voltage to come on? Ihave checked all of the fuses and power relays.

If you can provide me with the model year and engine, I can look it up for you.\015\012Let me know\015\012Regards, ... Volvo S70

1998 Jeep Grand Cherokee 5.9 V8. Radiator cooling fan motor burnt up. Need to find replacement. What we are finding only have 2 wires coming out of motor, we had 3. Connecting wires have 3. What do these three wires do and where can we find the correct part? We have been quoted everything from $63 (for the one with 2 wires) to $700+ (the guys swears this is what we need and can order it). Help!

Since the 5.9 electric fan motor cannot be purchased anywhere but from the dealership and for several hundred dollars, here's how I replaced mine. 1998-2000 Ford Crown Vics, Lincoln Town cars and Mercury Grand Marquis have exactly the same electric m ... 1998 Jeep Grand Cherokee

1997 pontiac sunfire, i have a 2 pin connector loose, but i dont know where it goes. it is on the passenger side close to headlight, all lights work. it is a black and yellow wire taped in the harness that holds the connection that goes to the radiator. having trouble with the cooling fan not coming on, checked fan motor, changed the coolant temp. sensor, havnt driven it yet, was wondering it that could have anything to do with the fan

There is a yellow and black wire in the wiring diagram that is for the low coolant sensor in the overflow tank. Your model may not use this sensor. ... 1997 Pontiac Sunfire

I am repairing a toyota camry and the fuses to the radiator cooling fans are good , i checked the fan by direct current and they work but the fans when properly connected do not work, a wiring problem is not obvious so what might be the problem. the car is 1997

Fan relay is the most comon on those check temperature switch as well that sends the signal to trigger the fans to kick on ... 1999 Plymouth Grand Voyager

I have a 1991 GMC K3500 with a 7.4 engine. The truck is equiped with a factory auxiliary cooling fan in front of the condensor coil. It will not come on now and the engine temp wants to creap up over 210 when idling with a/c on. I have replaced the thermal switch in the right head as well as the fan motor,radiator,water pump,clutch fan,and a relay on the left fender. I proved out the ground wire on the thermal switch. The relay has a diagram on it but i'm unsure how it works! I don't know if the

... 1992 GMC Sierra K1500

Where can I find an online wiring schematic for a 2004 venture van?? after driving for awhile then sit and idle the temp gauge will max out. the fans cooling fans never run unless the ac is on. the gauge then will point the needle straight down to the 6 o'clock position. it will stay there until the battery is unhooked to reset gauge. i monitered the radiator temp w/elec multimeter. the coolant was 220f, fans not running, then coolant started to boil out.

The coolant fans are cut on threw the coolant temp sensor,then it tells the computer to send ground to the coolant fan relay.The relay is good,or the coolant fans would not come on with the ac.Now if there is air in the cooling system,the sensor will ... 2000 Chevrolet Venture

1988 Saab 900 non-turbo 8v. Although I am not overheating, and fuses seem ok, my driver side (cooling fan) fan comes on upon turning the ignition key on and upon start-up stays on. A/C not a factor as not hooked up and know already the passenger side fan is for A/C. Could this simply be a stuck thermoswitch located in top left of radiator? This seemed to start with both a new battery and replacing O2 sensor, with no wires or grounds disturbed. Thanks!

... 1988 Saab 900

Thermostat has been changed, radiator cooling fans wont kick on and the car still over heats. we checked the fuses and wiring and the fans run when direct connected to the battery. what next?

There is probly a fan sensor mounted on the block,and a lead that will go to the brain box or relay,if you have relay.check that also.hope this helps ... 1999 Mercury Cougar
  • Start your question with What, Why, How, When, etc. and end with a "?"
  • Be clear and specific
  • Use proper spelling and grammar
all rights reserved to the respective owners || www.carrestorationshop.com || Terms of Use || Contact || Privacy Policy
Load time: 2.1529 seconds