Having problems with your 2004 Ford Expedition ?

Where is the evaportator core on 2004 Expedition?

Posted / edited by AnonymousUser on : 22-01-2018

Answers :

You should find the evaporator core in the heater box, near the heater core. Never had one fail, unless physically damaged in accident or similar case.
Repair Help & Product Troubleshooting for 2004 Ford Expedition

Tips for a great answer:

- Provide details, support with references or personal experience .
- If you need clarification, ask it in the comment box .
- It's 100% free, no registration required.

Suggested Questions/Answers :

Where is the evaportator core on 2004 Expedition?


You should find the evaporator core in the heater box, near the heater core. Never had one fail, unless physically damaged in accident or similar case. ... 2004 Ford Expedition

Ten months ago the local Ford dealer replaced the heater core and temp blend door on my '98 Expedition. The heater core failed again and I was told that due to oxidation I will basically continue to have this problem. The system was flushed when I had the first core replaced. Does this failure make sense? Is there something else that should have been done the first time the heater core was replaced?


There may be a corrosive in the system. Flushing the system should be done at least every 2 years. Your vehicle is now 12 years old, but I have not seen a heater core go bad in 10 months, it may have been defective, and should have some type of warra ... 1998 Ford Expedition

My name is Joyce and I have a question about the heater core on my 1998 Ford Expedition. My husband is outside trying to replace the heater core on it and he is trying to take the whole dash apart. We are having a really hard time. Could you please tell me if we have to take it all apart or is there some other way that we can replace the heater core? We have the manual for it but it just seems really difficult to do, is it as difficult as it looks? PLEASE HELP......LOL


You have the manual so you are ahead of most who try this, the only thing i can tell you is that is not the worsy one to do, lmao ... 1998 Ford Expedition

1999 ford expedition heater core leaking so I blocked off the lines there is still some dripping, could that be water left in the core or condensation from air condition.


... Cars & Trucks

Where is the heater core hose in my 2000 ford expedition?


Check closer to just underneath the firewall--it could be a smaller problem than a heater core--Ford 4.6--5.4 engines have a tube just underneath the intake manifold that the rubber hose goes bad and it will leak towards the back of the engine.Lets h ... 2000 Ford Expedition

I have a 1999 Ford Expedition SLT, 4.6L, 2WD, I hear water splashing in the dash and radiator fluid leaking out of the rear heater core overflow hose, I had the front heater core replace two years ago. Has anyone else had this proble, and if so how do I correct this problem.


Hi the problem with the coil rusting out is that it accumulates a/c water and it's not draining out fix the draining problem and then replace coil core good luck ... Ford Expedition

Hi. I have a Ford Expedition Eddie Bauer 99' form brand new. My problem now is that the heater is not working. In Straus auto service change the heater core, the thermostate and another square piece that go togheter with the heater core. I don't remember wath is. Any way. In Straus auto service don't paid nothing because I give complaint. Now I get appoimente in Ford dealer to fix my problem. Do you have idea about this problem?


Maybe the blower motor is not working, they give no warning signs, they just quit. If you tap lightly on it, it might blow just to get you by for now. ... Ford Expedition

I have a 2001 ford expedition my front heater core was leaking so i by-passed it. now its the rear heater core can someone please tell me how to by-pass it to. please


Greetings, Just remove the heater hoses where they go in to the firewall, and connect them together with a short piece of copper pipe and a couple heater hose clamps. Or, remove the hose that goes from the water pump t ... Cars & Trucks

Hi I have a 2000 Ford Expedition. I had front and rear heater core replaced by a mechanic. Front heater works great but now the rear heater blows warm not hot air. Took it back and the mechanic flushed the system but rear heater still blowing warm air. Mechanic insist its the climate control switch but it was blowing hot air before the rear new heater core was installed..... Does anybody knows what it could be? Please help


Is the correct type of heater core that use for rear heater?Check fan fix its correct side,or wiring change or return water line is blocked. ... 2000 Ford Expedition

There isnt coolant going through the heater core, therefore no heat. Is there a valve or could the core be blocked with something? It's a 99 Expedition Eddie Bauer.


Yes very common you will have to flush it out using a garden hose with good water pressure. disconnect both hoses connect one to the hose and turn the water on keep switching to back flush it until clean water runs out of it. reconnect hoses and it w ... 1999 Ford Expedition

Rear heat not working in 1999 ford expedition. I have the rear panel off and manually operated blend door. Can actually see actuator is working also. Will try air lock bleed but I should do it on front heater core and not the rear heater core?


... 1998 Ford Expedition

How to flush heater core for 2001 expedition - 2001 Ford Expedition


... 2001 Ford Expedition

Replacing heater core on 97 ford expedition - 1997 Ford Expedition


To replace the heater core the dash board need to be take apart. ... 1997 Ford Expedition

Heater core removal on a 99 ford expedition - 1999 Ford Expedition


To remove the heater core on this truck the entire dash must be removed, the A/C drained, and the coolant drained, once the dash is out you can access the environmental station, which houses the a/c and heater cores. The heater hoses to the core and ... 1999 Ford Expedition

How to remove heater core in 1998 expedition - Expedition Ford Cars & Trucks


... Ford Expedition

2000 Ford Expedition heater core control valve


I have the same problem...leaking from the heater core$700 to get repaired.well its not that hot were i live so oh well. good luke dude. ... Cars & Trucks

99 expedition rear heater core line bypass?


... 1999 Ford Expedition

1999 Ford Expedition rear heater core


... 1999 Ford Expedition

How to replace front heater core in 2001 ford expedition


... 2000 Ford Expedition

How to replace front heater core in 2001 ford expedition


... 2000 Ford Expedition

How to bypass rear heater core in a 99 ford expedition?


... 1999 Ford Expedition

How to replace front heater core in 2001 ford expedition


... 2000 Ford Expedition

Replacing the front heater core in a Ford 2001 Expedition


The best I can recommend at this time is go to auto zone and ask if they can provide a diagram print out for you I have a Haynes book and it states: to pull off the cover of the heater core/evaporator core housing it has small screws and then pull th ... 2000 Ford Expedition

98 expedition heater core


Call around, different garages have different labor rates.It's the job of putting these things in that cost so much. You might find one cheaper, and you may not. ... 1998 Ford Expedition

Heater core replacement 1999 expedition


Heater Core \015\0121. Disconnect the battery ground cable \015\0122. Drain the engine coolant. \015\0123. Remove the instrumental panel. \015\0124. If equipped with the 5.4L 4V engine, remove the junction block splash shield. \015\0125. If equipped ... 1999 Ford Expedition
  • Start your question with What, Why, How, When, etc. and end with a "?"
  • Be clear and specific
  • Use proper spelling and grammar
all rights reserved to the respective owners || www.carrestorationshop.com || Terms of Use || Contact || Privacy Policy
Load time: 0.3423 seconds