Having problems with your 2004 Dodge Caravan ?

Blower Fan Removal

\015 The blower fan started working intermittantly. I could reach under the dash and hit the fan and it would work...for awhile. Now it has quit. I started removeing the fan but I can't get to the back screw. It is located in a very tight spot. I am using a 8mm socket on a spring extension and a 3" and a 6" solid extension but the screw won't turn. Any suggestions on how to get this screw out?\015 Posted / edited by AnonymousUser on : 15-01-2018

Answers :

Repair Help & Product Troubleshooting for 2004 Dodge Caravan

Tips for a great answer:

- Provide details, support with references or personal experience .
- If you need clarification, ask it in the comment box .
- It's 100% free, no registration required.

Suggested Questions/Answers :

2006 honda accord 4-cyl. The blower fan doesn't work. When it is disconnected, the 12v to the blower fan connector is there--as soon as I hook it back up the fan starts to spin then immediately stops--12v is now 0v. I removed the blower fan and it spins when hooked up to an external 12v supply, drawing about 2 amps.


... 2006 Honda Accord

2001 town and country minivan,I'm trying to replace the blower fan,am having trouble removing the blower fan cover. i have removed 4 screws and it feels like the back of the cover still has a screw in it. How do you get to the back screw?


... 2001 Chrysler Town & Country

1999 Oldsmobile Alero 3.4 ltr v6 Problem is in the Heater/AC Fan Blower. Blew fuses. Took out the fan Blower and found frozen water at the base of the motor and didn't allow the fan to turn. Removed the ice, unfortunately had to replace the blower resistor, put it back together and works great. My daughter just called and said it wasn't working again. Is this a leak in the window? That's what I've been reading. If so, take it too a auto glass place to re seed? Why is this common for Ale


There is a technical Service Bulletin that covers the exact thing you are describing. I would post a copy of the bulletin here, but it is copyrighted material, so I'll just give you the details....\012\012Open the hood and remove the wip ... Oldsmobile Alero

Fan blower started running full speed, even after car turned off. And A/C does not work. Removing fuse (30A A/C?) stops the blower. Blower now runs normally, with fan speed switch able to adjust blower speed, but of course A/C doesn't work now.


THE FAN BLOWER RELAY IN STUCK CLOSE POSITION.YOU HAVE TO REPLACE FAN BLOWER RELAY. ... 1998 Pontiac Grand Prix

I have an 1997 Oldsmobile Aurora and my fan for the heat and a/c will not turn on. My brother checked both fuses in the front under the drivers seat and the big fuse under the back seat and they are all good and he has removed the glove box to try and get to the blower fan but not sure how to tell if it is working or not. So I am not sure of the next step. Should I replace blower fan or take to a garage and they will sock it to me and the car is really not worth much to put alot of money into


First check the blower motor resistor for burnt or melted wires or connector.It should be down at bottom of heater box towards center right.It will have two sets of wires going to it and i think maybe only two screws that hold it in place usally this ... 1997 Oldsmobile Aurora

Car is shut off, switch is verified as off, key out of ignition. Fan for blower (heater / air conditioner) stays on. Also, When car is on, fan blower adjustment for speed does nothing. Back to car off, even removing fuses in the car, AND fuses and relays under the hood, would not shut off the fan


Check blower motor regulator for moisture and corrosion on connectors ... 2004 Pontiac Grand Prix

My confort control blower remains running when ignition switch is off and key removed from ignition switch. the only way to shut down the blower is to remove the large fuse from the box under the hood. also there is no fan speed control, blower remains at constant speed. this problem occured suddenly.


... 2004 Chevrolet Impala

Mice in blower fan. How can I remove fan assembly


What is further amazing they get in through the evaporator drain tube .Unfortunately this means their habitat is also inside that evaporator housing where the coils are. I have had to completely remove the evaporator housing before to adress this iss ... 2000 Honda Accord

03 chevy tracker V-6.. heater blower fan not working.. I checked the fuses under the dash and the ones under the hood those are good.. If I need to replace the heater blower fan how is it removed..??


... Chevrolet Tracker

2005 Hyundai Santa Fe, Blower fan keeps blowing even after hitting the "Off" button, all parts look to be OK after removing dash control center, is there another electrical component that can go bad? The blower kept blowing even AFTER the whole AC/heater panel was removed.....


... 2005 Hyundai Santa Fe

How to remove and replace a vectra c blower fan


... Cars & Trucks

1977 Ford F-250 removing heater blower fan


Hello your heater blower fan is located in your heater box pass you will see a stop sign shaped flat flared end metal piece about 6inches diameter all the way around held in with either 6 or 8 1/4bolt heads unscrew these unplug wire feed pry light ... 1997 Ford F250 SuperCab

How to remove the blower fan on a 2004 caravan


... 2004 Dodge Grand Caravan

Blower Fan Removal


... 2004 Dodge Caravan

How to remove the blower fan switch on 2003 santa fe


To remove the knob, put it on the second speed setting and pull! Center piece and outer knob will pop right off. Found the answer elsewhere and it ought to be here too. ... 2003 Hyundai Santa Fe

1997 Lexus LS 400 --Fan blower not getting voltage or signal from heater relay. (actually module and fan not seeing voltage). Without a scan tool, I cant read the computers' would be sine wave. Ive removed fan and checked its operation by simply putting 12 volts to it. It runs great. Last link in the chain is supposed to be the heater relay. Any ideas, or experience w/same...Please advise....Theroad


Change the fan resistor it should be located under dash near the glove box ther's a rectangular electrical plug going to it it should be located somewhere on the heater box. These usually go bad because of the constant condensation and temp. changes ... 1997 Lexus LS 400

I removed my blower fan resistor from my 1992 buick lesabre and the fan started working on high speed only now won't work again could I have burned something up by running the fan without the resistor


Why did you remove the resistor for?Was the blower not working correct?Is that the same resistor?You can go to Autozone and get a resistor and install,if it doesn't fix the problem,take it back.,check power going to motor.Check fuse. ... Cars & Trucks

I just had the blower motor relay changed. I still here the noise of a fan running at the bottom of the windshield after I have removed the key from the ignition. is there another fan moter that has to do with the recirc? it appears that this is the fan that is draining my battery and causing me to jump start the car lately.


This is probably not a relay problem.\012Blower motor resistor usually the cause of this.Very common.\012Depending on year and model of your car the location of resistor may vary.\012And yes it's draining the battery.\012Resis ... BMW X5 Series

A/C BLOWER A/C is cool but fan in glove box is not turning. Is it the relay or blower motor? Where is the relay located and how to remove blower motor from glove box?


Most likely its the blower motor resister and is located behind the glove box. there are a few philips head screws you will need to remove inside the glove box and under the glove box to get the glove box out after that it should be a walk in the par ... 1998 Lexus Gs 400

Have a 2002 monte carlo ss. The ac wont come on ,nor the blower. If i shut the blower fan the Cruise contro light comes on. I checked the fuses and they are good. Also when i removed the ac/fan fuse the blower started working and stopped when it was replaced. If this is a relay problem , where is the relay located?


... 2004 Chevrolet Monte Carlo

Blower fan removal from 97 ford contour


Http://www.autozone.com/shopping/repairGuide.htm?pageId=0900c152800a8c41 ... 1997 Ford Contour

How do you remove the blower fan from a 2006 hummer h3


... 2006 Hummer H3

How To Remove Heater Blower Fan?


... 2003 Dodge Caravan

Where is the blower motor located in a 1999 Camaro? How much of this car do I need to disassemble to get to it? My 87 Buick GN was easy,under the hood on top of the blower box, Three screws and the electrical connector, 10 mins, done. Is this gona be one of those deals requiring pulling the engine and removing the rear license plate to get this done? It does not run on any speed setting. I don't think that there is a resistor on the ''High'' fan speed position. Thanks for any help. Robert


If I remember right,the right, front,inner fender has to come out,and then you will see it.Not to bad to remove,clips,and screws,and pull it out,just enough to get to the blower motor.Then the process is pretty much down hill,just removing screws fro ... 1999 Chevrolet Camaro

I have a 2000 Toyota Echo and need to access the heater blower fan. The filter apparently fell in the squirrel cage and became confetti. After removing the glove box and 5 or 6 screws on the outside of the heater box, I still can not figure out how to get inside to change the heater blower motor? I vacumed out the box as good as possible throught the filter door and replaces the filter but the motor makes a loud noise on high and does not work efficiently.


Did you ever get this resolved? I have the same issue with our 2000 Toyota Echo. ... 2002 Toyota ECHO
  • Start your question with What, Why, How, When, etc. and end with a "?"
  • Be clear and specific
  • Use proper spelling and grammar
all rights reserved to the respective owners || www.carrestorationshop.com || Terms of Use || Contact || Privacy Policy
Load time: 1.2601 seconds