Having problems with your 2004 Chevrolet Silverado 1500 Crew Cab ?

Problematic gauge cluster

\015 The problem I am having with my 2004 chevrolet silverado is the tach, speedometer, and ampmeter are intermittantly not working correctly. sometimes the gauges will function correctly until I turn off the truck then restart and the three gauges will go haywire. Any help is greatly appreciated and a big thanks in advance.\015
Posted / edited by AnonymousUser on : 15-01-2018

Answers :

This is a very common issue with these GM trucks! Here is a link to an instructable that may be of come help: DIY Finally How To Repair GM Instrument Cluster At Home Speedometer And...
This problem haunts gm & chevys alike computor glitch has most times been culprit .when this happens does shutting off waiting 5 min. then starting help?
Repair Help & Product Troubleshooting for 2004 Chevrolet Silverado 1500 Crew Cab

Tips for a great answer:

- Provide details, support with references or personal experience .
- If you need clarification, ask it in the comment box .
- It's 100% free, no registration required.

Suggested Questions/Answers :

Problematic gauge cluster


This is a very common issue with these GM trucks! Here is a link to an instructable that may be of come help: DIY Finally Ho ... 2004 Chevrolet Silverado 1500 Crew Cab

I have a 2004 Suburban. The gauge cluster was replaced due to theft. It works fine except that the "Driver Information Center" no longer behaves like it used to, or like the Owner's Manual says it should. Instead of "Personal" and "Business" it has "Trip 1" and "Trip 2". And within each it no longer has average mileage, etc. Did they install the wrong gauge cluster, in which case is a correctly functioning gauge cluster still available for this vehicle? (P/N?) Is it a gauge cluster swit


... 2004 Chevrolet Suburban

1991 gsxr 750 Is it possible or is there a way to install a eletric gauge cluster or a newer cluster on it? Its annoying not having a fuel gauge. Or if not able to put a eletric cluster is there a way to just install a fuel gauge?


... Cars & Trucks

On a 1987 thunderbird basic with a digital speedo and analogue gauges there is a short to the digital speedo display all gauges work but not the speedo. The issue is I have found a working cluster but on the old cluster I can not find the cause of the short and before I plug-in the new cluster I would like to know the reason for the short. Now for the question: The system includes Speed sensor, computer then the cluster and work in that order correct? The gages work, the cruse con


... 1987 Ford Thunderbird

After a jumpstart my fuel gauge and temp gauge suddenly went out but my oil pressure and voltage gauge still works. ive tried replacing the cluster, checked fuses, replacing my bcm, and checked for proper voltage going to my cluster..im lost i dont know what else to do.


What car is this on. There is NOT a BCM in a 2001 chevy s10 blazer. ... 2001 Chevrolet Blazer

2001 Dodge Dakota Quad 4.7 L with No BuS on the odometer. And the gas gauge and the rest of the clusters gauges will not work. The lights at the bottom of the cluster will work but thats it. I changed the ignition switch and it started and ran fine for a day. Then the next day I went to start it and drove into town and it quit again. But before that you could wiggle the key in the on off position and eventually gauges would come on. But now it won't even do that. Since it will not run, I have ch


I had the same problem on my 2001 Dodge Dakota. Then I noticed in addition to not having cluster backlighting, my parking lamps did not come on when I set the alarm or opened the doors. I replaced the 15 a fuse in the fuse panel for parking lamps. ... 2000 Dodge Dakota Quad Cab

Instrument cluster on 1997 Jeep Wrangler...gauges will work for a few seconds after start up..then all gauges stop working. Indicater lights in cluster seem to be ok. Have taken the cluster out several times and cleaned the contacts.


Faulty cluster may have to replace it. try testing a junked unit if it works keep it. ... 1997 Jeep Wrangler

99 mercury sable recently had the transmission rebuilt and now the speedometer and rpm gauges are not working....all the other gauges and lights in the cluster are functioning. the cluster was replaced and the new cluster is having the exact same issue. where should i start looking for electrical issues?


Does the odometer work?I would start by checking the fuses. ... Mercury Sable

Instrument cluster not showing odometer and speedometer and makes water temperature go straight to hot, fuel gauge stays on empty although its not empty and water is not empty in radiator and is not hot. Warning lights below dash show, oil, fuel gauge, fanbelt gauge, and also seatbelts warning lights stay on also. But nothing is wrong with the car. Its a high density Digital instrument cluster dashboard for a ea Ford Fairmont 1989 sedan.


It could be the voltage regulator for your instrument cluster is the problem. ... Ford Fairmont

I have a 1988 Cadillac Eldorado and my digital gauge cluster lights up and shows 0's speedometer and fuel gauge is not working car runs just gauge cluster not functioning I would like to know how I can fix this.


Replace it or have it repaired.There was a place in the midwest that repaired them but i don`t remember name. Sorry ... 1988 Cadillac Eldorado

I have a 2003 chevy trailblazer ext. The instrument cluster was failing. I had the cluster rebuilt but I still have an ABS light, parking brake light, battery light, and seat belt light. Also, the gas gauge, oil pressure gauge, battery guage, and temperature gauge do not work. Any solutions?


... 2003 Chevrolet TrailBlazer

FUEL GAUGE DOESN'T WORK, I ROEMOVED THE GAUGE CLUSTER TO CHANGE A BULB, WHEN I REINSTALLED THE CLUSTER EVERYTHING WORKS BUT THE FUEL GAIGE


Sounds like your going to be removeing it again.Take it back out and check the ribbon connecters to see if a copper strip has gotten rolled back or ripped off.While you have it out have a close look at the circut board for opens in any circut which y ... 2000 Buick LeSabre

Temp gauge goes to full hot. engine temp is good. gas gauge not accurate. fuses good looks like cluster is bad. is this possibly a diy remove and replace. where is the best place to get a replacement cluster. thx Brian


Sounds to me like you have two common failures on your car. One is the fuel sending unit in the tank (on the A4, which uses a similar design, this is a known issue, causing wrong or erratic readings on the gauge). The temp gauge is a failure of the ... 2002 Audi TT

I have a 2003 dodge neon with 40,000 miles... Speedometer and RPM gauges are all the way over to the right. I was told it's a problem with the cluster... All other gauges work... Will I need to have a new cluster installed????


... 1999 Dodge Dakota

The cluster gauges on a 1986 El Camino SS has stopped working. They were fine the day before. The temp, gas and voltage gauge are not working. Is there a fuse for this cluster? Thank you


I had this happen to my base model 1984 el camino (previous owner installed the ss guage panel because he wanted the tach).. i had gotten my transmission rebuilt then 2 days later as im heading to school i realize my gas guage, tach, and voltmeter we ... 1986 Chevrolet El Camino

I have a 200 mercury cougar 2.5 v6 and i have a problem with the computer system. it runs and idles fine but the electronics in the gauge cluster resets itself once an a while, and sit just the gauge cluster, the climate control and stereo work fine and don't turn off when a reset happens. what do i do?


For this problem straight solution is to use a diagnostic scan tool and retrieve fault codes which will tell you the exact problem. Could be bad earth or short somewhere or loose connection. ... 2000 Mercury Cougar

My 99 Silverado Instrument Cluster only has one gauge working, the Battery Volts. The Speedometer, Tackometer, Fuel, Mileage and Temp Gauge do nothing. I picked up another Cluster on EBay and it does the exact same thing. What could be causing this? Thanks


Mine is doing the same thing did you ever find a solution ... Chevrolet Silverado 1500

Computer problem? i have a 99 chevy blazer and the security light and high beams light on my dash cluster stay on constantly and on that occassion i get it started all the lights come on like the over speed, service 4x4, check engine light. pretty much every light in my gauge cluster come on. my gauges work but my odometer reads 000000


This is defiantly a CPU issue but, at the least, it could be a fuse box issue as well. check both to be safe.. oh, some stereos that are purchased and installed incorrectly can cause this as well. ... 1997 Chevrolet Blazer

Gauge Cluster Will it be easy for a non Honda Mechanic to Remove and Replace a Honda Civic Gauge Cluster?


YES ITS JUST A COUPLE OF PLUGS AND SOME DASH TRIM, ... 2003 Honda Civic

Temperature Guage Hello again Bob --- One point I missed in your answer to my problem. There is no wire from the gauge to the cluster. The cluster is designed with a printed circuit board. In the back of the gauge are 4 pins that plug into the circuit board. I hope this helps. Thanks again --- Chris --- from Miami


... 1998 Honda Accord

My main instrument cluster has "died" the speedometer,gas gauge and temp gauge all sit at zero and drive indicator does noit light up. Also the signal lights and brake lights don't work except the back window brake light.The car starts fine and runs and all the rest of the electical work, radio, a/c, fan, power adatpter. I checked all the fuses but did not see one associated with this main cluster. Is it a serious problem or is there a relay or fuse i can replace? Thanlks


... 2006 Dodge Grand Caravan

Fuel Gauge 96 Tracker fuel gauge went to empty amd stays there. i pulled the cluster out and did not see any burn marks on the back. Do i have to replace the cluster?


... Geo Tracker

2002 chevy express 2500 5.7V8rnTemp gauge sticking at max after overheating. Replaced temp sensor & thermostat. Replaced inst. cluster. New cluster sticks open @ max just like the old one. Is there another item to be replaced which affects temp gauge?


There are 2 temp sensors one is the coolant temp sensor for ecm data and the other is engine coolant temp sender/switch for the guage. ... 2002 Chevrolet Express

1995 Honda Civic fuel gauge always shows full. I removed instrument cluster and moved gauge down by hand. The needle moves back to full when key is switched to acc position. I found no loose wires or bad connections at the instrument cluster.


Well, theres a sending unit/float in the tank that sends a signal thru\015\012wires to your instrument cluster's fuel gauge. You should have an auto\015\012electric repairperson determine where your problem lies. It's not often\015\012the needle's ju ... 1995 Honda Civic

Temperature gauge in my 140 S class 93 model not working, we have checked with local Benz service point , they have replaced the temperature switch, even though, in dash board cluster, the gauge needle always stand still, can we repair or , Do we have to replace dash board cluster complete ?


Check your fuse it should be bad ... 2008 Mercedes-Benz S-Class
  • Start your question with What, Why, How, When, etc. and end with a "?"
  • Be clear and specific
  • Use proper spelling and grammar
all rights reserved to the respective owners || www.carrestorationshop.com || Terms of Use || Contact || Privacy Policy
Load time: 0.2882 seconds