Having problems with your 2002 Chevrolet S-10 ?

Where is the relay found on S10 2002 pick up truck 2.2lite for the secondary air injection pump

Posted / edited by AnonymousUser on : 22-01-2018

Answers :

Repair Help & Product Troubleshooting for 2002 Chevrolet S-10

Tips for a great answer:

- Provide details, support with references or personal experience .
- If you need clarification, ask it in the comment box .
- It's 100% free, no registration required.

Suggested Questions/Answers :

Where is the relay found on S10 2002 pick up truck 2.2lite for the secondary air injection pump


... 2002 Chevrolet S-10

Where can i find a diagram for 1999 malibu for the secondary air injection for p0410. i went to kragen manual and read as fast i can on engine side or emission side and nothing mention about air pump removal or installation. I went to electrical diagram and found no wiring about sec air injection or air pump connect to pcm or relay. can you show me or sent me a picture or diagram to see it. thank you


Hi\015\012\015\012The secondary air injection pump ,pumps air into the exhaust to help heat the catalytic converter at cold start. This lowers the emissions at an otherwise high emission time. A malfunction means that computer has registe ... Chevrolet Malibu

My S10 blazer lacks power, bogs under acceleration, recently truck would not start, took it to a garage and they replaced the injections module( "spider injection module, complete unit"), truck still lacks power and bogs under acceleration. took it back to the garage and they hooked up the scan tool once again, did a bunch of tests, said the fuel pump is on the low side of the spec. I replaced fuel pump and fuel filter and the truck still lacks power, the garage said the idle air control mod, th


Sounds to me like a bad fuel pressure regulator. I would replace that and see what happens, if that fails you may have contaminated fuel ... 2000 Chevrolet Blazer

2008 Chevy Cobalt w/72k - I have issues with secondary air injection. (2) days after steering recall done I start getting - Code, P0411,P2431 with P2440 - Secondary Air Injection System Switching Valve Stuck Open (Bank 1) was latest code. Think I found the problem - pump was FULL of water. Emptied best I could, tried to disassemble but (2) of T20 torx heads stripped, cut slots in them and still just can't turn them. So reinstalled and works for now (does not sound good) but my question is how d


... Chevrolet Cobalt

My 2000 S10 V6 secondary air injection pump stays on after the engine is turned off. Sometimes it runs for hours which drains the battery. The pump and relay have been replaced but the pump is still sticks on. Now I can't get it off without disconnecting the battery. Any remedies?


It would have to be a short somewhere in the wiring.The pump gets power from the A.I.R. relay. The pump circuit is from a 30amp fuse that gets power from a 175amp main battery circuit.But the relay magnet is powered by a 10amp fuse from the ... 2001 Chevrolet S-10

I have a 2000 chevrolet venture van I had a p0410 reading and found out it was the secondary air injection pump . I located it and checked it out and it runs but when you start the van it makes a loud


These pumps are notorious for failing, replace it and make sure all the hoses to and from the pump are in good condition, replace any that seem deteriorated. ... Cars & Trucks

Secondary air injection air pump - Cars & Trucks


... Cars & Trucks

How should the air pump in my secondary air injection system in my 99 chevy tahoe 5.7L 4x4 run ? Should it always be pumping air in or should it only run for the first few minutes whenever the motor


It runs only when the engine is below a present coolant temperature, it never runs after that. The purpose is to burn off excess hydrocarbons. ... 1999 Chevrolet Tahoe

Secondary air injection pump relay j299 - Volkswagen Cars & Trucks


... Volkswagen Cars & Trucks

I have a 2001 ML430 Mercedes Truck. When I start the engine in the morning, there is a small intermittent screeching sound coming from the secondary air injection pump, which goes away after a couple of minutes. Then everything is normal during the day, as long as I don't press the gas pedal too deep, in which case the RPM go up briefly and then drop, and the check engine light turns on. Then, if I start driving moderate speed again, the light goes off after a day or two. I took the car to the M


Possibly a vacuum line through these open ie not sealed conduits checks are not fissure-two may be a low pressure and does not require the more and engine performance is required to stabilize, as it is not a constant failure if it does not register a ... Cars & Trucks

Location of 2003 s10 secondary air injection pump


Lower right frton of engine compartment. Its electric not driven by engine ... Chevrolet S 10

Were is the secondary air injection pump - Cars & Trucks


In what make and model and year please ... Cars & Trucks

How to fix secondary air injection pump - Cars & Trucks


... Cars & Trucks

I have a 2001 Chevy s10 zr2 and new secondary air injection pump won't come on ...I've checked all fuses and changed relay


... Cars & Trucks

2000 chev truck secondary air injection pump - 1999 Chevrolet Silverado 1500


... 1999 Chevrolet Silverado 1500

S10 secondary air pump - Chevrolet Cars & Trucks


... Chevrolet Cars & Trucks

I have a 2001 gmc jimmy wiTh a secondary air injection code. bought THE VEHICLE used and had the code checked in the summer because it is hard to start it turns over,i replaced the fuel pump relay i also checked the fuel pressure without it running the pressure was 58 psi.now during the winter it wont start unless i use starting fluid then it runs fine,could the SAI KEEP IT FROM STARTING I ALSO FOUND A 30 AMP FUSE BLOWN BESIDE THE BATTERY WICH I BELIEVE IS FOR THE SAI AND A RELAY AND A 10 AMP FU


I have water in oil ... 2001 GMC Jimmy

Diesel Truck. I Have a 2004 Diesel f-350 super duty truck. Plain and simple, it wont start. I have taken apart the top fuel filter(close to the turbo hose) and found no problems, and the fuel pump works fine and pumps fuel into that second fuel filter. I found a blockage in the fuel filter and cleaned it up but it still wont start. *By the way it has air compression and the glow plugs work fine, it hits off of ether* Any tips?


Possible solution. I have an Edge Juice Programmer for my '04 6.0. While making the harness connections, I misjudged one connection and it wasn't completely in, causing truck to turn over but not start. Check on the driver's side front wheel well ... 2004 Ford F350

Secondary air injection pump, 01 GMC Jimmy V6


The 30A pump fuse and the 10 solenoid fuse are dedicated. The only other fuse in the circuit is 175A @ the battery. Look under the A.I.R. fuse block for melting around the relay ... 2001 GMC Jimmy

PO411 VW Jetta 1998 Secondary Air Flow issue, air injection pump does not work with 12 volts, 0.5 ohms, what is the correct resistance of air pump?


... Cars & Trucks

I have a 2006 pontiac grand prix with the check engine code po2440, secondary air injection valve stuck open. I have replaced the value twice, replaced the air pressure sensor, the air pump, a relay to the air pump, and a relay to the air valve. It has been a problem for me since Feb. and I still can't fix it. I took it to a mechanic/electrician and we still can't solve the problem. Any advice would help.


... 2006 Pontiac Grand Prix

Need to purchase secondary air injection check valves. Must I go through a dealer ? '01 Olds Intrigue. Air pump replaced 2 months ago , now informed I need above referenced parts. (Secondary air valves...need Bank1 and Bank2. Tried 2 local parts dealers no luck.


I would, get them from dealer, this way you get the right parts, i checked a couple of places also and no luck also, dealer can order parts if they dont stock them, if you want try rock auto.com. i just checked and they can get it.there are two types ... 2001 Oldsmobile Intrigue

Distributor problems?? I installed an accel distributor in my truck, found it was not compatible with computer for fuel injection. So, I went back to stock. I installed it found TDC aligned timing back to 0 noted the location of the distributor cap for number one firing position and connected wires in a clockwise fashion in the right firing order. Truck will not fire off now, I repeated the same steps three or more times, nothing. Any ideas?????


Are you certain you were on TDC of compression stroke? If you were on exhaust stroke, your dist. will be 180 degrees off.If timing is right, check for spark. You need to see a blue snapping spark at the end of the sparkplug wire to know ignitio ... 1989 Chevrolet Silverado 2500

My service engine light went on and brought codes P0492 & P0493 . I was told it was the secondary air injection system. I brought the car in to have it checked out and they said the secondary air pump needed to be replaced. I have not had it fixed yet because I was told it wasn't urgent, however, now by MPG gauge is malfunctioning and it never did this before. When I begin to approach a stoplight and I am coasting towards the light (not foot on either peddle) the gauge heads towards 40mpg. As so


I'm not sure if you fixed your problem yet but I had some similar gremlins on my 2001 540. Just a word of advice. Ensure that the tube from the air pump to the manifold is clear. This can occasionally get blocked and this is what causes the air pu ... 2001 BMW 5 Series

Fuel system I replaced fuel filter and my truck run for 1/2 an hour then stop I need to know if I have to bleed the fuel system to get the air out. For about six months now I have had a hard start problem, I have found if I let the fuel pump cycle 3 times just by turning the key on until the pump pressures up and stops it starts right up.I changed the fuel filter and gas cap as well, no difference found. It never dies and never hesitates runs strong all the time. Only just yesterday, going to w


Sounds like bad fuel pump. On the fuel pump there is a hose that goes from the pump up to the lines that feed your motor. That hose is about 4 inches long and is in the tank itself. I have had alot of those come through. You could replace the who ... 2001 Chevrolet Blazer
  • Start your question with What, Why, How, When, etc. and end with a "?"
  • Be clear and specific
  • Use proper spelling and grammar
all rights reserved to the respective owners || www.carrestorationshop.com || Terms of Use || Contact || Privacy Policy
Load time: 3.7146 seconds