Having problems with your 2001 Peugeot 206 1.6 ?

Peugeot 206 steering rack removal - 2001 Peugeot 206 1.6

Posted / edited by AnonymousUser on : 22-01-2018

Answers :

Repair Help & Product Troubleshooting for 2001 Peugeot 206 1.6

Tips for a great answer:

- Provide details, support with references or personal experience .
- If you need clarification, ask it in the comment box .
- It's 100% free, no registration required.

Suggested Questions/Answers :

Peugeot 206 steering rack removal - 2001 Peugeot 206 1.6


... 2001 Peugeot 206 1.6

Steering rack i have had multiple repairs for front end noises and thumping related to steering for 2 years, tie rods already replaced and now need replacement again(only 1 year old). and now i am being told my steering rack needs to be replaced. all these problems started while under warranty and now i'm past warranty and the big repair- the steering rack! what is the likelyhood that the steering rack was the problem from the start? what else could be causing problem? also i went through a set


Its possible that the mounting bushings for the rack are bad have the mechanic show you the mounts and look if they are wore out you can tell they wont look like they fit the car. the tierods warranty should have been extended when they were replaced ... 2003 Volkswagen Jetta TDI

Power Steering needs topping up daily & there's oil dripping to the floor, also the rack boot needs replacing. As we don't have $2'000 for a garage to "fix" the power steering problem, How hard is it to remove the power steering pump, hoses, rack & steering? & replace with a manual steering rack & steering? Do we need any extra special tools, or can a couple of back-yarders do this replacement?


If you are up to it, you can remove the Rack and Pinion and have it rebuilt. Most of the time the rebuild kits can be purchased locally, but I recommend you have it rebuilt by a professional. I usually just buy new Rack and Pinions and get the old on ... 1984 Subaru Brat

Peugeot 407 Hi, I have power steering rack leak problem with my 2009 model Peugeot 407 and I saw online oil like Lucas can stop this leak. But I understand its not suitable for Electronic Power Steering (EPS) like in my car. So, is there any other brand similar oil for EPS rack? And does it really effective?


NO "FIX IN A CAN" WILL PERMANENTLY SOLVE A RACK LEAK! MORE THAN LIKELY...IF EITHER END BOOT IS LEAKING...THEY ARE GENERALLY NOT REBUILT (EXCEPT BY O.E.M. SUPPLIERS). YOU ARE MOST LIKELY GOING TO NEED A NEW OR RE-MANUFACTIURED STEERING RACK.....SORRY! ... Cars & Trucks

On my rack and pinion the bolts sheared off and broke leaving me with two broken bolts inside the rack and pinion.I want to take it out and bench work the two bolts out what do I need to remove it? I have no steering how does it remove from the steering colum?


As far as removing steering from rack youll need repair manual for your car. bolts, drill a hole in middle of bolts and pound proper size E-Z out into hole. turn ezout to left to remove. good luck. ... 1995 Chrysler Concorde

55 Peugeot 407 - leakage from top of power steering unit through cap. Recently had new steering rack but still leaks causing steering to become heavy.


... Cars & Trucks

The power steering fluid is leaking from the driver's side rubber bellows at the end of the steering rack. I conclude that this is probably a failed seal at that point but in any case it will involve the removal of the rack from the car. Since I have had no previous experience with this model I would prefer to have some idea of what is involved before I start.


The steering rack seals can not be replaced . \015\012The only solution is to replace the steering rack. \015\012\015\012Very common failure. \015\012\015\012Good Luck, ... Volkswagen Beetle

I need Help, When I wiggle the ignition switch 1 out of 100 times the power will flicker on and off just for a sec. then nothing. I think I should remove the steering collum and see if there are any wires lose or need replaced. How do I do this? I have tried to remove the steering collum but it is harder than it looks. Please help.


Sounds like the ignition switch is on the fritz. ... 1983 Jeep CJ7

Power Steering Recently my power steering pipe blew and started leaking due to it comming in contact with the engine. Is it possible to remove and replace this pipe or is it a sealed unit to the steering rack?


It would be smarter to purchase a new pump....not worth the cost of labor to fix it. They run cheap...$65 or so. ... Ford F

Steering system I am in the process of intalling a rack and pinion. I removed the broken one, hooked up the new one, bleed the system and started the car to let it run for two min...per the intructions. however as soon as i touched the steering wheel to turn it the steering wheel rapidly moves left to right on it's own. Why is it doning that?


The hose on the rack not at the right place double check that if there ok and it wasnt doing that before the valve in the rack defect doing that i seen that it was the pressure line not the right place or broken inside the hose good luck HOPE IT FIXY ... 2000 Ford Windstar

While removing the steering rack of 97 Explorer (2wd), a little orifice dropped out of either the pressure or return tubing connection, i dont know which. The replacement rack does not have an orifice in either connection. Should I put this in the new rack, and if so, which port,and facing which direction? (This little thing is about 3/8"dia X 1/8"thick with "big" opening on one side and small orifice on the other)


Is there a way to get a picture of the item posted?You can also eMail it to [email protected] "sounds" like a flow restrictor, or tubing ferrule.It should go in with the smaller end first (like a cork).Thanks ... Ford Explorer

Steering/Suspension Mystery My S80 has over 100k miles, and I recently got a suspension job done, including : a. Both tie rods replaced b. Lower control arm bushing replaced c. Ball joints replaced d. Steering rack bush/stoppers replaced e. Full wheel alignment done. After all this work, the car does not seem to drive right. It has following symptoms: 1 On take-off, the steering pulls to the right, and drives straight with the steering tilted to right 2. On braking, the car pulls to


Ok after reading everything that you have posted I would recommend you getting a few more things checked:\015\012\015\012\015\012Try rotating the tires and see if an old wear pattern is causing what you are dealing with now and g ... 1999 Volvo S80

My mark x recently got the same problem with P/S light on but after hooked up with cpu system, the fault was removed and the steering back to service. But the problem at the moment is whenever I steer the wheel, I feel it was not as smooth as before. I did read few article and it might cause by few factors below which I need help for clarification . 1. Power steering fluid depletion? My mark x is having EMPS and hence is that any power sterring fluid reservoir? 2. Alternator efficiency?


... Cars & Trucks

Removal end installation on 1994 Lincoln Mark 8 Power rack end Pinion Steering Gear


... Lincoln Mark VIII

How do I remove the steering rack / 2004 chevy malibu classic


... 2004 Chevrolet Malibu Maxx

Removing Steering Rack from a 93 Mercury Sable


... 1993 Mercury Sable

How do I remove Power Steering Rack on my Ford


You may be able to remove it without removing the sub frame but I wouldn't reccommend it. The rack bolts to the sub frame from the top so it is actually much more difficult to remove them with the sub frame in place. I've replaced quite a few from fi ... 2003 Ford Focus

How to remove steering rack on 1993 olds ciera


... 1993 Oldsmobile Cutlass Ciera

Ignition hi my key broke in the ignition i have took the steering wheel off the ignition barrel is 1 piece with steering lock there is 2 bolts how do you remove them thankyou debbie


If you get a very strong magnet you may be able to get out without trouble. ... 1993 Mazda MX-5

Replacing the seals on my power steering gear. 4X4 tacoma. The problem is i am leaking from where the powersteering is connected to the steering u joints, i have the gasket kit, and i want to know if i can remove the smaller cast unit above the rack, where the high pressure lines come in.


... 1998 Toyota Tacoma

Told by gm dealer we need a new steering colum for our 2004 malibu maxx, $1,100.00,plus a rack because it is binding and leaking 586.00,plus a shaft 300.00? it has 140k miles. never in an accident all straight away highway miles from nj too baltimore. Sound right? no noise when turning wheel, couldn't the rack be seping?


Very rarely does the steering column go.....It sounds like you have a power steering fluid leak somewhere or the rack and pinion went bad. Go to a small garage and have them look at it if you can't. But, don't tell them what the Dealer said! They jus ... 2004 Chevrolet Malibu Maxx

Can the intermediate u joint assembly on the steering rack be replaced with out removal of the rack or column? 98 Toyota Avalon


... 1998 Toyota Avalon

1996 honda accord, 6 cyl, EX Both low beam headlights went out last night. As far as I know, they were working. Went to Walmart and bought a 2 pack headlisghts and put only 1 in and the low beam (new bulb) did not come on. Bright lights, turn signals, parking / running lights all work. Fuses checked out ok what's next? How do you remove the steering wheel column cover? I dont know if there is a relay or something between the switch on the steering wheel and the low beam lamps? Thanks, Bob


... 1996 Honda Accord

Do i need to remove the power steering pully or pump to replace the water pump? It seems to be in the way of 1 bolt, and if i do have to remove it, how does it come off?


NO,YOU DONT,THERE IS ONE BOLT,THAT YOU ARE NOT SEEING,RETURNLINE,PRESSURE LINE,MOUNTING BOLTS,AND COMES OFF,THEN,ONCE OFF,THEN REMOVE PULLEY ... 1997 Pontiac Grand Prix

Used 1999 Jeep GCL. Key stuck in ignition. Purchased a steering column for replacement at salvage yard. Vehicle is at repair shop. When he removed the old one, there was 1 wire that was not connected. He installed the replacement steering column and made all connections. When the car is started, it only runs for a few seconds and shuts down, on the dash the icon (circle with slash across it) lights up. He took the new one out and put the old one back in and now same thing happens. Is this someth


OK! I know this one well! Now the key sticking problem, I am not sure about, that is not the big issue, until you get it running. If you have an extra key, (I HOPE!) put it in the driver side door and lock and unlock it at least 5 times. That wil ... 1999 Jeep Cherokee
  • Start your question with What, Why, How, When, etc. and end with a "?"
  • Be clear and specific
  • Use proper spelling and grammar
all rights reserved to the respective owners || www.carrestorationshop.com || Terms of Use || Contact || Privacy Policy
Load time: 1.8514 seconds